Fireplace restoration for Oakleaf Plantation homes

Firebox, smoke chamber, damper and face, restored as one job in Oakleaf Plantation after a free look, with no hidden fees.

Fully licensed and insured
Locally owned
Family owned and operated
Same-day service

Call (904) 920-5495 Free Inspection

Get Your Free Inspection

Get a quote for chimney and fireplace repair and installation in Jacksonville.

Quicker by phone? Call (904) 920-5495

Call our chimney crew

(904) 920-5495 Free Inspection

Fireplace restoration experts for Oakleaf Plantation homes

Locally owned in Jacksonville
Family owned and operated
100% satisfaction guaranteed
Free inspection and estimate
Same-day service available
10% off any service

Heat-side repairs use refractory mortar; the face gets a softer mortar matched to the brick.

Family owned and operatedA family business plans your Oakleaf Plantation fireplace as one job, so each step happens once and in the right order.
100% satisfaction guaranteedYou approve the trial patch and the mortar sample before the face is touched, and our guarantee covers the result.

Call (904) 920-5495 Free Inspection

Gaps around the mantel and trim

Mantels, shelves and trim were often added to old fireplaces over the years, and some ended up closer to the opening than the building code allows. Wood trim near the opening can scorch, and a scorch mark is the warning to act on before it becomes more than a mark.

During restoration we measure combustible trim against the code's distances from the opening and note anything too close. Moving or changing trim is listed separately so you can decide on it. Mantel close to the firebox in your Oakleaf Plantation home? Have it measured free at (904) 920-5495.

The 2020 Census counted 31,034 residents in Oakleaf Plantation. Oakleaf Plantation is inland.

Clean, repair, repoint, protect

Smoke chamber parging restored
Seized dampers freed or replaced
Mismatched old patches cut out and redone
Drying times and the first fire date for your Oakleaf Plantation home

Call (904) 920-5495 Free Inspection

From first cleaning to first fire in Oakleaf Plantation

Clean and assess
Everything from the hearth to the flue top is cleaned, then checked and written up part by part.
Heat side first
Firebox, parging and damper repairs are made in refractory materials and left to dry.
Trial, then the face
A trial patch is cleaned and a mortar sample made for your approval before the face work.
Repoint, cure, clean
Face joints are repointed in layers, left to harden, then the face gets its final cleaning.

Soot on inland fireplaces in Oakleaf Plantation

Well away from the coast, soot is usually the face problem that brings people to restoration. It comes off in stages, tested first.

We show you a dried trial patch before cleaning the rest.

10% off any service booked within 72 hours of inspection

An old fireplace in Oakleaf Plantation can take several jobs to restore, and each one is discounted.

Call (904) 920-5495 Free Inspection

Parging the smoke chamber

Section R1001.8 of the Florida code requires the inside of the smoke chamber to be parged smooth with refractory mortar conforming to ASTM C199. In an old fireplace that parging may not have been applied at all, or it may have fallen away in patches.

A rough or open smoke chamber slows the smoke and leaves joints exposed to heat. Restoration fills and smooths it from below through the damper opening, and the repair dries for the time on the mortar's data sheet before any fire. The finished surface is checked with a light before we close up, and the ticket notes how much area was parged.

Filling deep joints in layers

Deep joints are not filled in one go. The National Park Service guidance has areas deeper than an inch filled first, then the whole joint built up in layers of about a quarter inch, each pressed into the back corners and left to reach thumbprint hardness before the next goes on.

Most mortar shrinkage happens as it hardens, and thin layers keep that shrinkage from opening a crack at the edge of the joint. It takes longer than packing the joint full, but the finished joint stays tight to the brick on both sides. On a fireplace face, that is what keeps a repair tight for years.

Taking smoke stains off brick

Smoke staining is its own category in the Brick Industry Association's cleaning guidance, which notes that scrubbing with a scouring powder, particularly one containing bleach, and a stiff bristle brush is often effective.

That is mild compared with what people reach for, and it is where we start, after a trial patch. How much comes off depends on how deep the stain has worked into the brick; some faces come up close to new and others only lighten. We tell you after the trial which to expect, rather than pushing harder chemistry at a stain that will not come out.

Safety work and face work on one page

Damper freed and rehung, or replaced where rusted through
Trial cleaning patch on the face, judged dry
Deep joints filled in thin layers and tooled at thumbprint hardness
Mantel and trim distances from the opening measured

Fireplace restoration questions from Oakleaf Plantation

Will all the soot come off?

That depends on the brick and how long the stain has been there. We clean a small trial patch first and show you the result once it is dry.

Is the restoration inspection free?

Yes. The inspection and the written estimate cost nothing, with upfront pricing and no hidden fees. Booked within 72 hours of that inspection, the restoration is 10% off.