Family-owned hearth repair for St. Nicholas fireplaces

Hearth repair in St. Nicholas built on a sound base, with grout, setting mortar and cure time named in writing.

Fully licensed and insured
Locally owned
Family owned and operated
Same-day service

Call (904) 920-5495 Free Inspection

Get Your Free Inspection

Get a quote for chimney and fireplace repair and installation in Jacksonville.

Quicker by phone? Call (904) 920-5495

Call our chimney crew

(904) 920-5495 Free Inspection

Hearth specialists who check the base first in St. Nicholas

Locally owned in Jacksonville
Family owned and operated
100% satisfaction guaranteed
Free inspection and estimate
Same-day service available
10% off any service

Your estimate in St. Nicholas names the setting mortar, the grout and the cure time.

Free inspection and estimateYour hearth in St. Nicholas is sounded, leveled and measured on a free visit before any price is written.
100% satisfaction guaranteedA tile or stone we set that comes loose is ours to fix, and we return to reset it.
Family owned and operatedA family-owned local crew explains each layer of the repair, from the support to the grout line.

Call (904) 920-5495 Free Inspection

Brick hearth units that rock

Brick laid flat as a hearth surface sits in joints that take foot traffic, heat and cleaning. When the joints crumble, the units loosen one by one, and a rocking brick at the front edge is the first to crack. Resetting a loose unit lasts only if the bed below it is sound.

We lift the loose brick on your St. Nicholas hearth, clean the bed down to firm mortar and relay each unit on a full bed with joints struck to match. The ticket lists how many units moved and what we found under them. Call (904) 920-5495 to book the free look.

Within Jacksonville city limits, St. Nicholas is its own named neighborhood. St. Nicholas falls within Duval County.

Hearth repair work we take on in St. Nicholas

Undersized extensions enlarged to the code size
Wood flooring cut back from the ember zone
Ash dump frames and lids reset or replaced
Factory-built hearth pads checked against the listing

Call (904) 920-5495 Free Inspection

How our hearth pros repair a hearth in St. Nicholas

Describe the hearth on the call
Cracked, hollow, sunken or too small, a short description sets up the free visit and what we bring.
Sounding and measuring
Each tile is tapped, the slab's level is read and the extension is measured against the opening.
Support first, surface second
A moving slab or missing support is fixed before tile or stone goes back on a full bed of the named mortar.
Cured before heat, then handed back
The bed cures before grout and fire, and we show you the finished edge and where the clear zone ends.

Where the effort goes on a hearth in St. Nicholas

With no coastal hardware to upgrade, a hearth repair in St. Nicholas spends its effort on the parts that decide how long it lasts: the support, the setting bed and the heat strip at the front.

The estimate for your hearth in St. Nicholas shows those three in order, so you can see where each part of the price comes from.

10% off any service booked within 72 hours of inspection

Resetting tiles or extending the hearth, either job comes 10% off.

Call (904) 920-5495 Free Inspection

Working out the 6 square foot line

R1001.10 switches from the smaller extension to the larger one at an opening of 6 square feet. The opening is its width times its height in inches, and 6 square feet is 864 square inches. A 36 by 24 inch opening lands exactly on the line. A 32 by 26 inch opening comes to 832 and falls just under it.

At or over the line, the extension runs 20 inches in front and 12 inches past each side. Under it, 16 and 8. The measurements and the arithmetic go on the ticket, so anyone can check the size we built to.

Bonding a clean break in stone

A stone hearth broken in two clean pieces can sometimes be glued back together rather than replaced. Stone repair epoxies are made for this, tinted to the stone and used as their maker directs. The joint is fitted dry first, then glued, clamped and cleaned off before it cures.

Gluing works only if the pieces are sound and the bed below is fixed, or the same break reopens beside the repair. Shattered pieces, chips missing from the joint, or a slab that cracked from heat are replacement cases. We show you the break and give you both options when both are real, with each one priced.

Level, height and the trip edge

A rebuilt extension has to meet the firebox floor, the finished floor and any doors at workable heights. A hearth set a little proud of the floor makes a trip edge. One set too high can foul glass doors or a screen. We check all three heights before choosing the slab thickness and the tile.

Where the numbers do not work together, the options are a raised hearth, a flush one with the slab set lower, or a small bevel at the front. We draw the section on the ticket, because a quarter inch at the front edge decides how the finished hearth feels underfoot.

What we check on a hearth in St. Nicholas before pricing

Slab level checked across the front and at both corners
Support under the extension identified, from below where access allows
Seam at the firebox cleaned and refilled with a heat-suited material
Ash dump frame reset in refractory mortar and lid fit checked

Before your hearth is lifted

Is the hearth inspection in St. Nicholas really free?

Yes. We measure and check the hearth, show you what we found and leave a written estimate at no charge. You decide afterward, with no pressure from us.

When can I light a fire on the repaired hearth?

That depends on the setting materials, and each product's data sheet gives a cure time before heat. We write that time on your ticket along with the date the work was finished.